Back to all

Tuffy Tire & Auto Service Plainfield Service for Your Exhaust System

July 12, 2022

Your vehicle's exhaust system is more than just a tailpipe and a muffler. In fact, it is one of the most complex systems on your vehicle.

drive

The manifold is attached to the vehicle engine. It collects exhaust from the cylinders and directs it into the exhaust pipe. Gaskets seal the connection of the manifold to the engine and to other joints. A cracked or loose manifold or a leaking or damaged gasket can allow dangerous gases to enter the passenger compartment of a vehicle. One of these gases is carbon monoxide, which is colorless, odorless and deadly. For this reason, it is important Plainfield residents keep their exhaust system in good repair.


The pipes that connect the various parts of the exhaust system can rust or be damaged by rocks or other road debris. Such damage can cause dangerous gases to leak into the air.

The catalytic converter is the next component of your vehicle exhaust system. It sort of looks like a muffler. Its job is to change dangerous gases into harmless carbon dioxide and water. The catalytic converter doesn't require any regular maintenance, but it can wear out. If it fails, you will need a new catalytic converter to pass an emissions test in Illinois. Call Tuffy Tire & Auto Service Plainfield at 815-436-1337 if you suspect a problem with your catalytic converter.

Oxygen sensors in the exhaust pipe monitor the oxygen content of the exhaust. This helps the vehicle engine's computer keep the fuel-to-air mixture at optimal levels.

The muffler is also part of your vehicle exhaust system, but it deals with a different kind of emission. It keeps your vehicle from emitting bad sounds. Mufflers act like finely tuned musical instruments. They create a feedback of sound waves to absorb or decrease the noises made by your engine. Different mufflers can create different sound waves, so you can actually “tune” your car to produce a particular sound, anything from whisper to rumble.

It is important that damaged mufflers be replaced immediately at your Plainfield automotive service center, especially if they are leaking. Not only will the extra noise annoy your Plainfield neighbors, a leaky muffler could be serious.

The entire exhaust system is attached to your vehicle by hangers and clamps. These fasteners can rust, come loose or break. The components of the exhaust system can get very hot, so when the hangers or clamps fail, these hot components can come into contact with other parts such as wires and hoses. These can melt, causing serious and damage to your vehicle. Good car care requires that you have your exhaust system inspected regularly.

Caring for your vehicle exhaust system at Tuffy Tire & Auto Service Plainfield yields cosmetic benefits like quieting your engine sounds, but also may impact your health and safety. Your life, or the life of a loved one, may actually be on the line.

Tuffy Tire & Auto Service Plainfield
23846 W 135th St
Plainfield, Illinois 60544
815-436-1337

 

More articles from Tuffy Plainfield

What is a TPS? (Throttle Position Sensor)

March 24, 2024

You know you have an accelerator pedal; step on it and your vehicle is supposed to go. But did you know there is a part in your vehicle that keeps track of where the throttle is? It's called the Throttle Position Sensor, or TPS. The TPS is a sensor that helps your vehicle figure out the right mi... More

The Third Brake Light (Third Brake Light Service)

March 17, 2024

So you thought you only had two brake lights. Look again and you'll see one in the center at a higher level than the two on either side of the vehicle. They're sometimes in the inside of the vehicle behind the back window, or they could be in the deck lid, on the roof or on the spare wheel carr... More

Muffler: Victim of Winter (Muffler Repair)

March 10, 2024

So you almost got through the winter until, one day, your muffler started sounding like a dragster, loud and obnoxious. It's not surprising. All that road salt and brine can cause rust to punch holes in a muffler, and that should raise a big, red warning flag about the safety of your vehicle. O... More